A New Fast-acting Sublingual Fentanyl (Recivit®) for Treating Breakthrough Cancer Pain

European Oncology & Haematology, 2014;10(1):12–6

Abstract:

Cancer pain presents a significant clinical challenge. Even when background pain is effectively controlled, patients often experience episodes of breakthrough cancer pain (BTcP), which typically reach maximum intensity in 10 minutes and last for 60 minutes. Immediate-release opioids are often used to treat BTcP, but only produce analgesia after 20–30 minutes and their full analgesic effect after 60–90 minutes, so transmucosal formulations of fentanyl citrate have been developed that produce analgesia more rapidly. A new sublingual transmucosal formulation (the FE tablet) utilises a unique three-layer structure and is available in dosages from 67 μg to 800 μg. This review summarises available data on the new formulation. In phase I trials, it has demonstrated dose proportionality, absolute bioavailability of approximately 70 % and higher plasma fentanyl concentrations than an oral transmucosal fentanyl citrate lozenge. In a prospective, randomised, double-blind, crossover study to evaluate efficacy and safety, pain relief was recorded from 6 minutes after administration onwards and lasted for up to 60 minutes.

Keywords: Breakthrough pain, analgesia, fentanyl citrate, transmucosal formulation, FE tablet
Disclosure: Andrew Davies has received an honorarium for attending an associated advisory board from Grünenthal GmbH.
Received: February 05, 2014 Accepted May 07, 2014 Citation European Oncology & Haematology, 2014;10(1):12–6
Correspondence: Andrew Davies, Royal Surrey County Hospital/St Luke’s Cancer Centre, Egerton Road, Guildford, Surrey GU2 7XX, UK. E: adavies12@nhs.net
Support: The publication of this article was supported by Grünenthal GmbH. The views and opinions expressed are those of the author and not necessarily those of Grünenthal GmbH.

Pain is a common feature of cancer that presents a significant clinical challenge. The prevalence of pain increases as the condition progresses1 and it affects over 80 % of patients with advanced disease.2 Opioids remain the best front-line treatment for providing pain relief (PR), but even when these agents effectively control background pain, patients often experience breakthrough cancer pain (BTcP).3 This may be defined as ‘a transient exacerbation of pain that occurs either spontaneously, or in relation to a specific predictable or unpredictable trigger, despite relatively stable and adequately controlled background pain’.4

BTcP is a heterogeneous entity that varies both between individuals and within individuals over time.5 In a recent study that enrolled 1,000 European oncology patients, the median number of BTcP episodes was three per day, with >95 % of subjects rating the intensity of pain as either ‘moderate’ or ‘severe’.6 Median time to peak intensity was 10 minutes, and the median duration of episodes was 60 minutes.6 The negative effect on quality of life can be significant, as a result of personal suffering and interference with the activities of daily living.6

BTcP may be classified as either spontaneous pain (episodes are unpredictable and not related to an identifiable precipitant) or incident pain (episodes are related to a specific identifiable precipitant).4 There are three sub-classifications of incident pain: volitional (brought on by a voluntary act such as movement), non-volitional (brought on by an involuntary act such as coughing) and procedural (related to a therapeutic procedure such as wound dressing).4 Episodes of pain that occur shortly before the administration of ‘around-the-clock’ (ATC) opioid analgesics (‘end of dose failure’) should not be regarded as BTcP, since the background pain is not controlled in this situation.

This review article summarises the available data on a new fast-acting fentanyl formulation for treating breakthrough pain, which has been developed to accelerate absorption of fentanyl and reduce the time to onset of analgesia.

Management of Breakthrough Cancer Pain
There is currently no ‘gold standard’ for the pharmacological symptomatic treatment of BTcP, but the most common strategy is the use of supplemental analgesia, or ‘rescue medication’.4 The ideal rescue medication should not only be safe and effective, but also have a rapid onset of action, a relatively short duration of effect7 and be suitable for use both reactively (i.e. at the onset of pain) and prophylactically (i.e. prior to the onset of pain in patients with predictable incident pain). These properties would enable BTcP to be rapidly controlled, while avoiding opioid accumulation and minimising adverse effects.8 Currently, BTcP is widely treated with supplemental doses of oral opioids – often immediate-release formulations of morphine. The time to onset of analgesia for these agents is 20–30 minutes, and the time to full effect 60–90 minutes.4 This is not ideal for managing many BTcP episodes.

The requirement for an agent with a faster onset of effect led to the development of transmucosal formulations of fentanyl citrate. Fentanyl is well suited to transmucosal administration because it is highly lipophilic.9 Currently available formulations include oral transmucosal fentanyl citrate (OTFC), fentanyl buccal tablet (FBT), orally disintegrating tablet (ODT), fentanyl buccal soluble film (FBSF), intranasal fentanyl spray (INFS) and fentanyl pectin nasal spray (FPNS). Randomised controlled trials have shown that these formulations can produce analgesia within 15 minutes, and are generally well tolerated.10–15 Recent recommendations published by the European Association for Palliative Care state that ‘BTP can be effectively managed with oral, immediate-release opioids or with buccal or intranasal fentanyl preparations. In some cases the buccal or intranasal fentanyl preparations are preferable to immediate-release oral opioids because of more rapid onset of action and shorter duration of effect’.16

A continuing area of concern with transmucosal fentanyl formulations is that aberrant drug-related behaviour is likely to emerge in about 10 % of patients,17 so continuous monitoring is required. It is generally agreed that the best approach to this problem is not by limiting the availability of these agents, but by the proper assessment and management of both pain and addiction.18

A New Formulation
The conventional approach to tablet formulation is to distribute the active ingredient uniformly throughout the whole tablet, which means that the total dose is not available until the tablet has completely dissolved. In the context of BTcP, the rapid onset of effect is of paramount importance, and a new formulation of sublingual fentanyl citrate tablet (FE tablet) has been developed with the aim of accelerating absorption. It has a unique three-layer structure with a neutral central core surrounded by the fentanyl citrate layer (see Figure 1). This, in turn, is surrounded by an alkaline outer buffering layer, which provides the optimal pH for dissolution and subsequent absorption (see Figure 2). Following dissolution of the surface layer, the total dose of fentanyl is rapidly available, in contrast to a conventional tablet, where the whole amount of fentanyl will only become available after complete dissolution.

The small triangular FE tablet has a neutral taste [data on file]. In vitro testing has shown that it takes approximately 10 minutes for 80 % of the FE tablet to dissolve compared with approximately 1 hour for the OTFC lozenge (Actiq®; see Figure 2; data on file). Six dosages are available: 67, 133, 267, 400, 533 and 800 μg. The tablet is placed under the deepest part of the tongue and allowed to completely dissolve without chewing or sucking. Any remnants may be swallowed after 30 minutes. The optimal dose is determined by upward titration on an individual patient basis, with a maximum of two tablets for each BTcP episode. The range of dosages allows dose escalation in 133 or 267 μg increments until adequate analgesia is achieved. Once an appropriate dose has been established, this should be administered for subsequent BTcP episodes, up to a maximum of four doses per day. If the response to this dose changes markedly, it may be increased or decreased by one increment to maintain an optimal effect.

Pharmacokinetics
The pharmacokinetics of the new FE tablet have been investigated in four phase I trials in healthy adult volunteers under fasting conditions.19–22 The OTFC lozenge was selected where an active comparator was required, as this product has been on the market for the longest period of time.

Dose-proportionality
A drug is said to be dose-proportional if its concentration (usually in plasma) at any given time is proportional to the dose administered. This property is of clinical importance in predicting the effect of dose adjustments, because it means, for example, that doubling the dose will double the plasma concentration. Drugs that lack dose-proportionality are more difficult to use, particularly if the therapeutic window is narrow.

The dose-proportionality of three different doses (133, 400 and 800 μg) of the FE tablet has been investigated in an open-label, randomised, three-way crossover, six sequence, dose-proportionality study.19 Thirty-three subjects were included in the statistical analysis. They received a different single dose on each of three occasions and were then followed up for approximately 2 days, with a 14-day washout phase between doses. Blood samples were collected at various time intervals up to 36 hours after dosing, and the plasma concentration of fentanyl determined using a validated liquid chromatography– tandem mass spectrometry (LC/MS/MS) method. From the area under the plasma concentration-time curve (AUC) (see Figure 3), pharmacokinetic parameters including AUC0-t, AUC0-t’, AUC0-inf and the maximum concentration (Cmax) were then derived. Analysis of these parameters and a linearity analysis performed using a regression approach, demonstrated that these three doses have linear and doseproportional pharmacokinetics after single-dose administration.19

References:
  1. Shrijvers D, Pain control in cancer: recent findings and trends, Ann Oncol, 2007;18(Suppl. 9):ix37–ix42.
  2. European Society for Medical Oncology (ESMO): Minimum clinical recommendations for the management of cancer pain, Ann Oncol, 2005;16(Suppl. 1):i83–i85.
  3. Portenoy R, Hagen N, Breakthrough pain: definition, prevalence and characteristics, Pain, 1990;41;273–81.
  4. Davies AN, Dickman A, Reid C, et al., The management of cancer-related breakthrough pain: recommendations of a task group of the Science Committee of the Association for Palliative Medicine of Great Britain and Ireland, Eur J Pain, 2009;13:331–8.
  5. Portenoy RK, Treatment of temporal variations in chronic cancer pain, Sem Oncol, 1997;5(Suppl. 16):S16–7-12.
  6. Davies A, Buchanan A, Zeppetella G, et al., Breakthroughcancer pain: an observational study of 1000 European oncology patients, J Pain Symptom Manage, 2013;46:619–28.
  7. Zeppetella G, Opioids for cancer breakthrough pain: a pilot study reporting patients’ assessment of time to meaningful pain relief, J Pain Symptom Manage, 2008;35:563–7.
  8. Zeppetella G, Breakthrough pain should be distinguished from background pain, Guidelines in Practice, 2009;12:19–26.
  9. European Monitoring Centre for Drugs and Drug Addiction. Available at: http://www.emcdda.europa.eu/publications/ drug-profiles/fentanyl (accessed on 4 November 2013).
  10. Coluzzi PH, Schwartzberg L, Conroy JD, et al., Breakthrough cancer pain: a randomized trial comparing oral transmucosal fentanyl citrate (OTFC) and morphine sulfate immediate release (MSIR), Pain, 2001;91:123–30.
  11. Slatkin NE, Xie F, Messina J, Segal TJ, Fentanyl buccal tablet for relief of breakthrough pain in opioid-tolerant patients with cancer-related chronic pain, J Support Oncol, 2007;5:327–34.
  12. Rauck RL, Tark M, Reyes E, et al., Efficacy and long term tolerability of sublingual fentanyl orally disintegrating tablet in the treatment of breakthrough cancer pain, Curr Med Res Opin, 2009;25:2877–85.
  13. Mercadante S, Radbruch L, Davies A, et al., A comparison of intranasal fentanyl spray with oral transmucosal fentanyl citrate for the treatment of breakthrough cancer pain: an open-label, randomised, crossover trial, Curr Med Res Opin, 2009;25:2805–15.
  14. Rauck R, North J, Gever LN, et al., Fentanyl buccal soluble film (FBSF) for breakthrough pain in patients with cancer: a randomized, double-blind, placebo-controlled study, Ann Oncol, 2010;21:1308–14.
  15. Portenoy RK, Burton AW, Gabrail N, Taylor D, for the Fentanyl Pectin Nasal Spray 043 Study Group. A multicenter, placebo-controlled, double-blind, multiple-crossover study of fentanyl pectin nasal spray (FPNS) in the treatment of breakthrough cancer pain, Pain, 2010;151:617–24.
  16. Caraceni A, Hanks G, Kaasa S, et al., Use of opioid analgesics in the treatment of cancer pain: evidencebased recommendations from the EAPC, Lancet Oncol, 2012;13:e58–e68.
  17. Passik SD, Messina J, Golsorkhi A, Xie F, Aberrant drug-related behavior observed during clinical studies involving patients taking chronic opioid therapy for persistent pain and fentanyl buccal tablet for breakthrough pain, J Pain Symptom Manage, 2011;41:116–25.
  18. Passik SD, Kirsh KL, Weighing in on the off-label use of Actiq for non-cancer related pain: a recipe for success or a recipe for disaster?, Pain Med, 2007;8:130–3.
  19. [PK1] Ethypharm (Saint Cloud, France) Study 009, Data on file, 2011
  20. [PK2] Ethypharm (Saint Cloud, France) Study 010, Data on file, 2011
  21. [PK3] Ethypharm (Saint Cloud, France) Study 004, Data on file, 2009
  22. [PK4] Ethypharm (Saint Cloud, France) Study 011, Data on file, 2012
  23. Darwish M, Kirby M, Robertson P Jr, et al., Absolute and relative bioavailability of fentanyl buccal tablet and oral transmucosal fentanyl citrate, J Clin Pharmacol, 2007;47:343–50
  24. Novotna S, Valentova K, Fricova J, et al., on behalf of the ETHYFYL Study Group, A randomized, placebo-controlled study of a new sublingual formulation of fentanyl citrate (Fentanyl Ethypharm) for breakthrough pain in opioid-treated patients with cancer, Clin Ther, 2014;36:357–67.
Keywords: Breakthrough pain, analgesia, fentanyl citrate, transmucosal formulation, FE tablet